2019 Alfa Romeo Stelvio Complete Service & Maintenance Schedule

• The 2019 Alfa Romeo Stelvio requires an oil change at least every 12 months or 10,000 miles (16,000 km), whichever comes first, with an oil change indicator system that may trigger as early as 3,500 miles based on driving conditions
• Brake fluid replacement is mandatory every 2 years, regardless of mileage - a time-based safety requirement that applies to all Stelvio variants
• Spark plugs require replacement at 30,000-mile intervals (mileage-based only; yearly intervals do not apply) - this differs from 2020+ models which have a 60,000-mile interval
• The accessory drive belt under normal (non-dusty) conditions requires replacement at 36,000 miles or 4 years; in dusty areas or demanding use, at 18,000 miles or 2 years
• Transfer case oil replacement (AWD models only) is a mandatory operation in the 2019 maintenance plan - this applies specifically to Stelvio AWD versions
• Severe duty operation (dusty roads, off-road use, extended idle, short trips below freezing) requires oil changes at 4,000 miles (6,500 km)
• Owner periodic checks (fluid levels, tire pressure, lights) are required every 600 miles (1,000 km) or before long trips
• In dusty areas, the engine air cleaner cartridge and cabin air filter must be replaced every 10,000 miles (16,000 km)

Scheduled Servicing Overview

The 2019 Alfa Romeo Stelvio follows a structured maintenance plan based on both distance and time intervals, as detailed in the official owner's manual. Correct servicing is crucial for guaranteeing a long life for the vehicle under the best conditions .

How the System Works:

• Alfa Romeo has planned a series of checks and services at fixed intervals based on distance and time
• Scheduled Servicing is offered by an authorized dealer according to a set time schedule
• Before each service, follow the instructions in the Scheduled Servicing Plan (periodically check fluid levels, tire pressure, etc.)
• If additional replacements or repairs are needed beyond scheduled operations, they require the owner's explicit consent

Critical Warranty Note:

Scheduled Servicing intervals are required by the manufacturer. Failure to have them carried out may invalidate the New Vehicle Limited Warranty. You are advised to inform your authorized dealer of any small operating irregularities without waiting for the next service .

Oil Change Indicator System:

The actual interval for changing engine oil and replacing the engine oil filter depends on vehicle usage conditions and is signaled by the warning light or message in the instrument panel. The system adapts depending on your driving habits - it may be as soon as 3,500 miles or as far away as 10,000 miles, but regardless of the indicator, a synthetic oil and oil filter change should occur no later than 10,000 miles or 12 months, whichever occurs first .

Owner Periodic Checks (Between Services)

The following checks are the owner's responsibility between professional service visits. These should be performed every month or every 600 miles (1,000 km) or before long trips :

Engine Oil Level:

Every 2,000 miles (3,000 km), check and top off the engine oil level if required .

Heavy Usage & Severe Duty Conditions

If the vehicle is used under any of the following conditions, more frequent maintenance is required :

Checks Required More Frequently Under Heavy Usage :

• Check cleanliness of hood and liftgate locks, cleanliness and lubrication of linkage
• Visually inspect conditions of: engine, transmission, pipes and hoses (exhaust/fuel system/brakes) and rubber elements (sleeves/bushes, etc.)
• Check battery charge and battery fluid level (electrolyte)
• Visually inspect conditions of the accessory drive belts
• Check and, if necessary, change engine oil and replace oil filter
• Check and, if necessary, replace cabin air filter
• Check and, if necessary, replace air cleaner

Severe Duty - All Models :

Change engine oil at 4,000 miles (6,500 km) if the vehicle is operated in a dusty and off-road environment or is operated predominately at idle or only very low engine RPM. This type of vehicle use is considered Severe Duty.

Factory Maintenance Plan - 2.0L Engine

The following maintenance plan is extracted from the official 2019 Alfa Romeo Stelvio Owner's Manual. The table shows key services at mileage intervals for the 2.0L T4 MAir engine :

Legend: (mandatory) = Mandatory operation | (o) = Recommended operation

Table Notes:

(1) Top up using the fluids indicated in the "Fluids And Lubricants" section only after checking that the system is intact

(2) If oil degradation ratio (data collectable from diagnostic device) is more than 80% (oil quality less than 20%), engine oil and filter replacement is recommended

(3) The actual interval for changing engine oil and replacing the oil filter depends on vehicle usage conditions and is signaled by the warning light or message in the instrument panel. In all cases, never exceed 1 year/10,000 miles (16,000 km)

(4) Accessory Drive Belt: Non-dusty areas: max 36,000 miles (60,000 km) or every 4 years. Dusty areas/demanding use: max 18,000 miles (30,000 km) or every 2 years

(5) If the vehicle is used in dusty areas, this cleaner must be replaced every 10,000 miles (16,000 km)

(6) Brake fluid replacement must be done every two years, irrespective of mileage

(€») The spark plug change interval is mileage-based only. Yearly intervals do not apply

Complete Service Schedule by Mileage - 2.0L Engine

10,000 - 50,000 Miles

60,000 - 100,000 Miles

110,000 - 150,000 Miles

*(o) = Recommended operation, (mandatory) = Mandatory operation*

Engine Oil Change Guidance

Oil Change Indicator System:

The actual interval for changing engine oil and replacing the engine oil filter depends on the vehicle usage conditions and is signaled by the warning light or message in the instrument panel. It may be as soon as 3,500 miles or as far away as 10,000 miles, but the system adapts depending on your driving habits .

Maximum Limits:

• Never exceed 1 year between oil changes
• Never exceed 10,000 miles (16,000 km) between oil changes
• The warning light may indicate a need for earlier changes based on driving conditions

Oil Degradation Monitoring:

If the oil degradation ratio (data collectable from the diagnostic device) is more than 80% (oil quality less than 20%), engine oil and filter replacement is recommended .

Severe Duty: 4,000 miles (6,500 km) if operated in dusty/off-road environments or predominantly at idle/low RPM .

When You May Need an Oil Change Sooner:

• Check engine light is on
• Knocking noise coming from the engine
• Oil smell inside the vehicle
• Excess amount of vehicle exhaust
• Hauling heavy loads
• Driving in dusty terrain or off-road
• Driving at low speeds for long distances

CAUTION: Never overfill the engine with oil. Excess oil can damage the engine. Never exceed the MAX level when topping up .

Brake Fluid - 2-Year Mandatory Interval

Brake fluid replacement is a mandatory operation that must be done every 2 years, irrespective of mileage .

Why Every 2 Years:

Brake fluid is hygroscopic - it absorbs moisture from the air over time, which lowers the boiling point and can cause brake fade under hard braking. Moisture also promotes internal corrosion of brake system components.

Owner Check: If the brake fluid level is insufficient during the monthly check, see an authorized dealer as soon as possible .

Spark Plugs - Mileage-Based Only

Replacement Interval :

• 30,000 miles (mileage-based only)
• Yearly intervals do not apply

Important Note: The 2019 model year has a 30,000-mile spark plug interval. This is different from 2020-2024 models which have a 60,000-mile interval for the same 2.0L engine. Use only spark plugs specified by Alfa Romeo for the Stelvio engine. Incorrect plugs can cause misfires, poor fuel economy, and engine damage.

Replacement Schedule in the Plan: Spark plugs are shown as Mandatory replacements at 30,000, 60,000, 90,000, 120,000, and 150,000 miles .

Accessory Drive Belt

The accessory drive belt(s) require visual inspection of condition and tensioning at every scheduled service .

Replacement Intervals :

Owner Guidance: When replacing belts, consider replacing tensioners as well. The highest cost of this service is the labor, not the replacement part itself. Reusing old tensioners risks premature failure and repeating the entire expense.

Factory Schedule Note: The maintenance plan shows accessory drive belt replacement as a Mandatory operation at 150,000 miles/15 years, but the 36,000-mile/4-year interval applies under normal conditions .

Transfer Case Service - AWD Only

The transfer case oil replacement is a mandatory operation for AWD models only . This applies specifically to the Stelvio AWD system (分å¨çæ²ä»…适ç¨äºStelvio车åž) .

The transfer case enables power transfer between the front and rear wheels. It contains chain-driven gears that move through fluid to keep components cool, well-lubricated, and corrosion-free.

Factory Replacement Interval:

The 2019 factory maintenance plan specifies transfer case oil replacement as a mandatory operation at 80,000 miles / 8 years .

Symptoms That Indicate Transfer Case Service is Needed:

• Transfer case fluid is dark and discolored
• Transfer case fluid level is low
• Rattling or grinding noise coming from underneath the car
• Repairs have been completed on the transfer case

Critical Warning: When the transfer case fluid is replaced, only the exact manufacturer-specified fluid should be used - using the incorrect fluid will cause premature failure.

Engine and Cabin Air Filters

Engine Air Cleaner Cartridge :

• Normal conditions: Replace per maintenance schedule (shown at 30,000, 60,000, 90,000, 120,000, and 150,000-mile intervals)
• Dusty areas: Replace every 10,000 miles (16,000 km)

Cabin Air Filter (Passenger Compartment Cleaner) :

• Normal conditions: Alternating recommended (o) and Mandatory operations at most service intervals (every 10,000 miles)
• Dusty areas: Replace every 10,000 miles (16,000 km)

Engine Coolant

Engine coolant replacement is a mandatory operation in the maintenance plan, scheduled at 150,000 miles (15 years) . Coolant level should be checked monthly (every 600 miles) and topped off as needed.

Cooling System Notes: The 2019 Stelvio has two cooling systems (engine coolant and intercooler coolant), both of which need to be checked to ensure proper fill levels .

Additional Service Components

Fuel Filter:

Replacement of the additional fuel filter (if equipped) is required at every 10,000-mile service interval as a mandatory operation .

Battery:

Check battery charge status with the proper instrument at every scheduled service (every 10,000 miles / 1 year) .

Tires:

Check tire condition/wear and adjust pressure at each service. Check the tire repair kit recharge condition and expiration date .

Brake System:

Visually inspect conditions and wear of front/rear disc brake pads and operation of pad wear indicators at every service .

Lighting System:

Check operation of headlights, direction indicators, hazard warning lights, trunk lid lights, passenger compartment lights, glove compartment lights, and instrument panel warning lights at each service .

Wiper System:

Check position/wear of front windshield wiper blades and operation of the windshield wiper/washer system at every 10,000-mile service .

Quadrifoglio (2.9L V6) Maintenance Notes

For the 2019 Stelvio Quadrifoglio (2.9L V6), additional maintenance operations apply :

• Visually inspect the brake discs surface and edge - this is a Quadrifoglio-specific operation
• Brake pads/brake discs replacement: The actual interval for changing the brake pads and the carbon ceramic brake discs depends on the vehicle usage conditions and is signaled by the warning light or message on the instrument panel. After each disc replacement, the warning light must be reset using the diagnostic socket

Note: Owners of Quadrifoglio models should consult the owner's manual's Quadrifoglio section for specific spark plug and other interval details, as the 2.9L engine has different requirements than the 2.0L.

Summary of Key Maintenance Intervals

Warranty Coverage

The 2019 Alfa Romeo Stelvio includes the following warranty coverage :

• Basic warranty: 4-year / 50,000-mile comprehensive vehicle warranty (bumper-to-bumper)
• Anti-corrosion warranty: 3-year, unlimited mileage limited warranty
• Federal emission warranty: 8-year / 80,000-mile

Free maintenance is standard for the first year of ownership .

Extended Coverage Options :

• Alfa Romeo Service and Care: 3-years/30,000-miles or 4-years/40,000-miles of additional maintenance coverage
• Alfa Romeo Maximum Care: Coverage of up to 5,000 critical components with term options up to 8-years/125,000 miles