2006 Aston Martin DB9 Coupe Service Schedule & Maintenance Guide

Key Takeaways

• Primary Service Interval: 16,000 km (10,000 miles) or 12 months, whichever occurs first; a free initial service is required at 1,500 km (1,000 miles) / 3 months .
• Initial 1,000-Mile Service: Free of charge at the selling dealer; includes inspection, oil and filter change, and fine adjustments to compensate for initial 'bedding-in' .
• Brake Fluid: Must be renewed every 12 months to clear the system of absorbed water vapour and maintain hydraulic performance .
• Engine Oil Specification: 0W-40 or 5W-30 synthetic meeting Ford WSS-M2C929-A or MB 229.5 approvals; capacity is approximately 11.0 liters .
• Warranty: 3-year/unlimited mileage vehicle warranty from first registration .
• Service Documentation: Full Aston Martin service histories are highly valued and enhance resale desirability, with low-mileage examples often showing annual servicing regardless of use .

Introduction: Understanding Your 2006 DB9's Service Needs

The 2006 Aston Martin DB9 Coupe represents a significant model in Aston Martin's modern history. Powered by a hand-built 5.9-litre V12 engine producing nearly 500 bhp, it was the first car to be built at the marque's new Gaydon facility .

The DB9 is a grand tourer that rewards meticulous maintenance. The manufacturer recommends a structured schedule divided into 16,000 km (10,000-mile) or 12-month intervals, whichever comes first . The owner's manual stipulates that failure to perform these service items on time may void the New Vehicle Warranty . Due to the sophistication of the vehicle's systems, owner maintenance is generally restricted to routine checks and procedures described in the Owner's Guide .

Official Factory Service Schedule

Primary Service Interval Overview

The 2006 DB9 follows a structured annual service schedule. The schedule is built around the following milestones :

Brake Fluid Renewal

To maintain hydraulic brake system performance and safety, the brake fluid is renewed every 12 months to clear the system of absorbed water vapour . This is a critical safety item—brake fluid absorbs moisture over time, which lowers its boiling point and can lead to brake fade under hard use.

Service Documentation

For the 2006 DB9, service history is paramount. A documented example with just 8,548 miles had 11 service stamps and numerous invoices from Aston Martin, demonstrating meticulous care . Another example with 41,200 miles showed a comprehensive service record with entries from HWM Aston Martin and other specialists, including a new radiator fitted at the 10-year service .

Engine Oil Change Guidance

Factory Specifications

The 5.9L V12 requires regular synthetic oil changes. The factory-recommended interval is every 16,000 km (10,000 miles) or 12 months .

Key Specifications:

• Engine Oil Capacity: Approximately 11.0 liters (basic capacity) .
• Recommended Viscosity: 0W-40 or 5W-30 fully synthetic.
• Approvals: Ford WSS-M2C929-A, MB 229.5, BMW LL-01, VW 502.00/505.00 .
• API Specification: API SN .
• ACEA Specification: A3, B4 .

Owner Guidance: The engine oil level should be checked every fourth fuel tank fill or weekly—whichever is the soonest. Running the engine with oil below the lower mark or above the upper mark can cause serious engine damage. The DB9 is often sold with complementary Mobil oil pouches, and examples have been documented as always having been looked after, including the provision of an Aston Martin battery tender .

Key Service Items at Major Milestones

20,000-Mile Service (2nd Year)

At the 20,000-mile / 24-month service, technicians will:

• Replace synthetic engine oil and oil filter .
• Replace brake fluid .
• Replace the in-cabin air filter .
• Perform a tire rotation .

30,000-Mile Service (3rd Year)

At 3 years / 30,000 miles, technicians will:

• Replace synthetic engine oil and oil filter .
• Replace engine air filter .
• Replace ancillary drive belt .
• Perform a tire rotation .
• Complete the factory 131-point maintenance procedure .

Fuel Filter

Changing the fuel filter is part of the long-term repair and maintenance schedule. Many car companies recommend changing the fuel filter every 5 years or 50,000 miles, but the owner's manual for the DB9 will provide the specific interval .

Warranty and Extended Coverage

Manufacturer Warranty

The 2006 DB9 is covered by a 3-year / unlimited mileage vehicle warranty and a 10-year / unlimited mileage anti-perforation warranty .

Extended Warranty Options

At the end of the 3-year period, Aston Martin offers an optional extended Premium service contract that can extend coverage up to 10 years / unlimited mileage on vehicles less than 10 years old .

Coverage includes components such as:

• Engine, cooling system, and intercoolers
• Air conditioning
• Gearbox/transmission, clutch, differential/final drive
• Wheel bearings, steering, suspension, brakes

An alternative plan is available for cars between the ages of five and 10 years old, with unlimited mileage at a total aggregate claim limit of the maximum value of your car .